Viessmann Vitocell 200 Cylinder Manuel de service

Design, Installation,User & ServicingInstructionsAn unvented hot water storage appliance complying with the requirements of Building Regulations A

Page 10INSTALLATIONINSTALLATIONGeneral Design ConsiderationsThe cupboard footprint needs to be at least 650mm square for units up to 300 litres

Page 11INSTALLATIONINSTALLATIONGeneral Restrictionsa. The highest hot or cold water draw off point should not exceed 10 metres above the Pressure Re

Page 12INSTALLATIONINSTALLATIONTypical Discharge Pipe Arrangement15 mmdischargepipeExpansionreliefvalveDotted line showingalternative route withsingle

Page 13INSTALLATIONINSTALLATIONd) It is preferable for the discharge to be visible at both the tundish and the final point of discharge but where this

Page 14INSTALLATIONINSTALLATIONSafetyCut-outThermostatImmersion Heater WiringELNTemperature/Pressure Relief ValveThis safety device is also pre-set at

Page 15INSTALLATIONINSTALLATIONHeating/primary SystemsThe boiler and primary/heating systems should be sized and installed in accordance with BS 5449.

Page 16Schematic Solar System With Viessmann Boiler As Solar ControllerSolar Pumping StationSolar PanelExpansionVesselSolarControllerNoteEnergy cutout

Page 17INSTALLATIONINSTALLATIONMixed HW outMains CW inFigure 1: Cold port of the blending valve connected to mains supplyNOT ALLOWEDMixed HW outMains

Page 18INSTALLATIONINSTALLATION1 98765432 10TS1S11 barSolarPumping StationSolar CoilC1 2C1+ Co+ CoL N230 VAC 5 ampMains SupplyDual ThermostatVies

Page 19INSTALLATIONINSTALLATION1 98765432 101112N L 1 2 3 4OFF ON OFF ONHW CH1 2 3 4Room ThermostatCentral Heating ControlC12C1Dual Aqau StatOverheat

Page 2Section PageDESIGN Description 3 Technical Data 6 System Details 8 INSTALLATION Installation 10 Commissio

Page 20INSTALLATIONCOMMISSIONINGCommissioningConnections can come loose in transit, and all should be checked before installation.Ensure th

Page 21USER INSTRUCTIONSUSER INSTRUCTIONSUser InstructionsYour Viessmann Vitocell 200 Cylinder is automatic in normal use, but requires routine mainte

Page 22SERVICINGSERVICING AND MAINTENANCEMaintenanceThe Registered Installer is responsible for the safe installation and operation of the system. Th

Page 23SERVICINGFAULT FINDINGProblems And Remedial ActionScaleIn hard water areas it is recommended that an in-line scale inhibitor is fitted. Reducin

Page 24SERVICINGFAULT FINDINGFault - No Hot WaterSwitch onSet programmerRe-set, check wiring &plumbing is correctRe-setIs all wiring to thecontrol

Page 25SERVICINGFAULT FINDINGWater service check bysupply company requiredClean or replace straineras appropriateService /replace PRVas appropriateSTA

Page 26SERVICINGSPARE PARTS LISTSPARE PARTS LISTDescription QuantityGledhill Code No.Spares Part No.1 3kW immersion element 1 SH001 71607532 22mm 90°

Page 27APPENDIXAPPENDIX AVast quantities of water are needlessly run off to waste due to Taps, Mixers and Showers discharging flow rates far in excess

Page 28APPENDIXAPPENDIX BDescription Manual handling means any transporting or supporting of a load (including lifting, putting down, pushing, pullin

Page 29SERVICE INTERVAL RECORDSERVICE INTERVAL RECORDIt is recommended that your heating system is serviced regularly and that you complete the approp

Page 3DESCRIPTIONDESIGNSupplied By: Viessmann LtdMaximum inlet pressure toPressure reducing valve 12 barOperating pressure (PRV setting)

Page 30NOTES

Page 31NOTES

Viessmann Werke GmbH&Co KGD-35107 AllendorfTelephone: +49 6452 70-0Fax: +49 6452 70-2780www.viessmann.comViessmann LimitedHortonwood 30, TelfordSh

Page 4DESIGNDESCRIPTIONIntroductionViessmann Vitocell 200 Cylinder is a range of unvented hot water storage cylinders, manufactured in the

Page 5DESIGNDESCRIPTIONPipework is not supplied by manufacturer,but to be supplied and fitted by installer.Viessmann Vitocell 200-B Solar CylinderViess

Page 6DESIGNTECHNICAL DATA Table 1ModelWeight - EmptyWeight - FullCapacity (Total Volume)Pressure Regulator 3 bar inletgroup c/w balance cold supply

Page 7DESIGNTECHNICAL DATA Table 1ModelWeight - EmptyWeight - FullCapacity (Total Volume)Pressure Regulator 3 bar inletgroup c/w balance cold supply

Page 8DESIGNSYSTEM DETAILSViessmann Vitocell 200-V CylinderBasic Appliance1. Hot water draw off (22mm) compression2. Temperature & pressure rel

Page 9DESIGNSYSTEM DETAILS79311612121284510Viessmann Vitocell 200-B Solar CylinderBasic Appliance1. Hot water draw off (22mm) compression2. Tempera